Power Painter Pro Sprayer

$ 149.00
The Power Painter Pro provides features and controls to make big outdoor projects go fast.

With multiple production speeds and material selection settings, projects like garages, decks, fences and house painting and staining get done with a consistent finish.

Materials can be sprayed from the cup or the provided backpack for extended spraying.


Power Painter Pro Sprayer Overview
Power Painter Pro Sprayer Overview Video
Power Painter Pro Sprayer Cleanup
Power Painter Pro Sprayer Cleanup Video


  • Optimus dual fan pattern tip delivers a professional spray pattern
  • Sprays 8 gallons per hour
  • Remote suction set to draw material directly from can or backpack for big jobs
  • Convenient carry case for storage
  • Extra atomizer valve for latex or oil based material
Download Manual

Parts and Accessories

P/N 0525146
Suction Tube for 1 Quart Container (EZ Tilt Models)

Suction Tube for 1 Quart Container (EZ Tilt Models)


Buy Now
P/N 0525195
5' Remote Suction Set (EZ Tilt Models)

5' Remote Suction Set (EZ Tilt Models)


Buy Now
P/N 0199903
Piston for Power Painters

Piston for Power Painters


Buy Now
P/N 0016101
Piston Spring for Power Painters

Piston Spring for Power Painters


Buy Now
P/N 0525148
Seal Kit (EZ Tilt Models)

Seal Kit (EZ Tilt Models)


Buy Now
P/N 0525118
Atomizer Valve for Optimus & EZ Tilt Sprayers (2 Pack)

Atomizer Valve for Optimus & EZ Tilt Sprayers (2 Pack)


Buy Now
Power Painter Pro is rated 3.1 out of 5 by 9.
Rated 3 out of 5 by from Power Painter Pro with EzTilt Gallon Backpack didn't work as expected The unit works well however I bought this to use specifically with the 1 gallon backpack oiling a fence with Flood CWF-UV. Unfortunately the unit couldn't draw the stain up closer than six inches from the bottom of the sprayer. That was disappointing as I've got a lot of fence to stain and now I need to fill the small attached container quite often to get through ten gallons of stain. Do I recommend the quality and to buy it yes, for small jobs.
Date published: 2015-11-06
Rated 5 out of 5 by from Great sprayer for exterior projects I purchased this unit to paint the soffit and upper ends of my 24x40 barn. I sprayed VALSPAR paint/primer combination paint. I used cup as I was painting from a bucket lift and was concerned about spillage on the rental lift. I sprayed 2+ gallons in a matter of a few hours and am very pleased with the overage and performance of the unit. I had zero, no issues. I sprayed one end in an evening and then stored the unit (without cleaning) overnight and completed the job early the next morning... no clogs. The unit comes apart easily and cleaning is tedious but not difficult. Clearly the more thorough you clean the Atomizer, spray tip, suction tube, etc the less trouble you will have.... or buy replacement O-rings, piston and atomizer (not expensive) and just replace them... I cleaned them.. I will use it again in a few weeks to paint the porch ceiling of the barn (8x40' porch).. I will be able to assess if my cleaning job was successful at that point. I paid less than $100 for this unit new, online... a great deal and nice addition to my handyman tool assortment.
Date published: 2015-09-17
Rated 1 out of 5 by from Used it once then did not work. used it once a year ago and it worked fine. tried to use it today and could not get the paint to spray. followed all the instructions, oiled etc. was cleaned thoroughly last time and cleaned again before use this time. even tried the tube option but could not get paint to come up the tube -- yes, the paint was thinned and can at same level. tried for over two hours. nothing worked. really really annoying payed good money for this and don't have the time or money to replace.
Date published: 2015-06-06
Rated 3 out of 5 by from Too Heavy Power unit way too heavy especially if you have a full cup of paint. Also you can't find extra atomizers anywhere except online. I'll buy something else next time. Why buy this if you can't get parts locally? Would not recommend to anybody!
Date published: 2015-03-09
Rated 1 out of 5 by from Do not Buy I understand that any product can go bad.... I am not an expert but I do follow instructions as needed. Purchased this unit 2 years ago to spray my fence with redwood stain. It really worked well, cleaned it up and put it away. Today I started to paint the house. First area all masked off. Paint thinned and strained according to paint manufactures directions. Got a width area of abut 4 feet and the piston froze up. (yes it was oiled), Tried all the suggest in the Wagner Manual and then some. Unit went in the trash............ broke out the compressor with another sprayer to finish........what a disappointment, doubt if I will ever buy another simply because I cannot trust the sprayer to perform.
Date published: 2013-07-29
Rated 5 out of 5 by from Handy small sprayer I'm sure the hose is a pain and would clog so I never bother with it. The tilt feature is a must. I spray latex without a problem. When I clean the parts I am thorough and careful. I have discovered a great trick for frequent intermittent use of the same paint. You can store it full of paint for a week or more without emptying or cleaning. Just press a plastic baggie close onto the sprayer tip an hold as you give a short shot of paint, leave the baggie pressed on the tip to stay wet.
Date published: 2012-09-13
Rated 4 out of 5 by from you can roll wall in no time the roller feature is terrific. Pad for cutting in was okay but when I tried to clean it., the pad fell apart.but the pad is not a material feature to me anyways. But to roll a room it is very fast and efficient.
Date published: 2012-03-28
Rated 1 out of 5 by from Rather use a brush! When the product is new, it works great. BUT, over time it becomes more and more difficult to clean hoses and other attachments sufficiently to get the same mechanical results you have when it's new. And the thicker the paint, the worse of a product it is. Great idea, poor execution.
Date published: 2011-10-07
  • y_2018, m_9, d_21, h_22
  • bvseo_bulk, prod_bvrr, vn_bulk_2.0.8
  • cp_1, bvpage1
  • co_hasreviews, tv_0, tr_9
  • loc_en_US, sid_024964199778, prod, sort_[SortEntry(order=SUBMISSION_TIME, direction=DESCENDING)]
  • clientName_wagnerspraytech
  • bvseo_sdk, p_sdk, 3.2.0
  • CLOUD, getContent, 266.9ms

Will the SUCTION TUBE FOR 1 QUART CONTAINER (EZ TILT MODELS) Fit older sprayer models

Asked by: Marc
The EZ Tilt suction tube does not fit other models of Power Painters.
Answered by: Technical Support
Date published: 2018-07-30

I'm looking to buy the Power Painter Pro to paint my ceiling. Do you need to thin the latex paint ?

Asked by: Claude
The Power Painter Pro will spray most latex paint without thinning. You should be just fine, you can call our Technical Service at 800-328-8251 for further assistance if needed. Thanks for contacting Wagner!
Answered by: Technical Support
Date published: 2018-07-18

my wagner power painter pro was working great out of the box, then i refilled the cup and started to spray more .. It went for about 10 seconds and quit, wont spray paint.. I cleaned it and went to spray again and it sprayed for about 10 seconds and stop.

Asked by: mountain biker
Sounds like the tip may be clogging up. The paint may need to be strained or stirred up well if it sat for awhile. Try calling our Technical Service for some troubleshooting help at 800-328-8251.
Answered by: Technical Support
Date published: 2018-07-11

What are the differences between the Power Pro Paint Sprayer, the Flexio 590, and the Flexio 3000

Asked by: Rugman
The Power Painter Pro is an airless handheld paint sprayer. It's designed for coating surfaces with a high production rate. The Flexio's are HVLP sprayers. They are lower pressure and use air to spray the paint. In general they have a lower production rate with a better finish than the airless power painter sprayers. The Flexio 3000 has the same specifications as the Flexio 590 but has the newer style I-Spray front end nozzle assembly. This has a revamped flow control and nozzle for better paint atomization and spray pattern. For more information you can contact our Technical Service at 800-328-8251.
Answered by: Technical Support
Date published: 2018-06-16

Can you use this to paint a car

Asked by: Ruben
If it cleans up with water or mineral spirits it should spray, but this isn't an automotive quality finish sprayer so it will not produce a showroom finish such as what you would generally want on a car. Please give us a call at 1-800-328-8251 if you would like further assistance with unit selection.
Answered by: Wagner
Date published: 2018-01-08

I purchased the POWER PROFILE PRO SPRAYER. However, the voltage is 120 volts and Korea is 220 volts. I'd appreciate it if you could tell me how to use it. And let me tell you how many watts of power it consumes.

Asked by: DW KIM
If you mean the EZ Tilt Power Painter that is sold in North America then it is designed to be used with 110volt current. The products sold here are not designed to be used with 220 voltage. To determine wattage you multiply volts by the amps.
Answered by: Wagner
Date published: 2017-12-18

What is the difference in functionality of an airless v the flexio series?

Asked by: Sid757
Airless sprayers atomize coatings by forcing the product through a small tip opening at very high fluid pressure. Airless spray transfer efficiency is higher than conventional air spray and offers the ability to spray the widest variety of coatings. Working fluid pressures range from 1200-3600 PSI and they are typically gas, electric, and air operated. The primary application is production work and they are capable of covering large areas quickly. Flexio sprayers are HVLP sprayers. HVLP stands for High Volume Low Pressure. HVLP sprayers atomize coatings by a high volume of air and low air pressure. HVLP sprayers are used for finishing work and are classified as a finishing tool. The three major components of an HVLP unit are the gun, the air hose (on some), and the turbine/motor. A high volume of air is supplied from the turbine/motor, through the hose and is diverted into the container. The air pressure in the container causes the paint to flow from the suction tube up into the gun where a large amount of low pressure air intersects with the paint stream to form atomization. Which one to use depends on your projects. If you would like to discuss this or have further questions feel free to call us at 1-800-328-8251.
Answered by: Wagner
Date published: 2017-11-26

Does Wagner Power Painter Pro can be used with Wagner HVLP Click and Paint Handle Extension?

Asked by: Martin80
The Power Painter Pro cannot be used with the HVLP handle extension. If you would like to discuss this you can call us at 1-800-328-8251.
Answered by: Wagner
Date published: 2017-09-13
  • y_2018, m_9, d_21, h_22CST
  • bvseo_bulk, prod_bvqa, vn_bulk_2.0.8
  • cp_1, bvpage1
  • co_hasquestionsanswers, tq_25
  • loc_en_US, sid_024964199778, prod, sort_[SortEntry(order=LAST_APPROVED_ANSWER_SUBMISSION_TIME, direction=DESCENDING)]
  • clientName_wagnerspraytech
  • bvseo_sdk, p_sdk, 3.2.0
  • CLOUD, getContent, 72.07ms